EGR removal Urmston
We come to you. OBD port connection. Around an hour. £220 fixed.
Mobile EGR removal across Urmston and the surrounding area, call 0161 694 7331 to arrange.
For off-road and track use only.
How a mobile EGR removal visit works in Urmston
Here is what to expect when we carry out an EGR removal in Urmston:
We arrive at your location.
Home, workplace, commercial yard, or car park, the vehicle stays exactly where it is. No recovery truck, no garage slot to book, no need to drive a vehicle that is already restricted to limp mode.
Pre-remap diagnostic.
We connect to the OBD port and read every current fault code before anything is touched. You get a clear picture of the vehicle's exact condition, EGR codes and anything else stored in the system.
ECU remap.
We write the modified ECU map that removes the EGR system from the engine's operating logic entirely. The valve stays physically in place, nothing is unbolted, nothing is removed from the engine bay.
Verification.
The modified map is confirmed, the engine is restarted, and the result is checked before we proceed.
Fault codes cleared.
All EGR-related codes are removed from the system. Done.
Most visits take 60 to 90 minutes from arriving to leaving. The vehicle is ready to drive when we pack up. You do not need to arrange recovery, take time off to reach a garage, or move the vehicle anywhere. If you have more than one vehicle at the same location, call ahead, we can often cover multiple units in a single visit.
What the modification does
We connect to the OBD port and read the current ECU map. The parameters that govern the EGR system are identified and rewritten so the ECU no longer activates the valve. The valve stays in the engine, no hardware removal, no blanking plates, no cutting. The engine operates without the EGR circuit in its logic, permanently.
“EGR removal” and “EGR delete” refer to the same modification. Both terms are used across garages, forums, and search results, the work is identical regardless of which was searched. The result is permanent: once the remap is written, the EGR logic is gone. All stored EGR fault codes are cleared at the end of the job. Because the ECU no longer runs EGR commands, those codes cannot return.
What it costs, and how that compares
The EGR removal is £220. That covers the visit, the remap, and the post-remap verification, one fixed price, nothing added on for the call-out or the diagnostic read.
For comparison, an EGR valve replacement on a typical diesel van runs between £300 and £600 in parts and labour, often more where bolts are seized or surrounding components need attention. Replacement addresses the failed component but leaves the operating conditions unchanged. The same stop-start, short-run duty cycle that fouled the original valve will foul the replacement. A software remap removes the EGR from the equation entirely, for less than the standard replacement cost.
For operators running more than one vehicle, the saving compounds per unit. If a DPF delete is also needed, the combined price is £445 and both modifications are completed in the same visit.
Covering Urmston and the surrounding area
Urmston is approximately five miles from our Eccles base, a short run with good motorway access. We cover Urmston town, Flixton, Davyhulme, Stretford, and the commercial and trade premises across the Trafford Park corridor. The volume of vans and light commercial vehicles operating in and around Trafford Park, one of Europe's largest industrial estates, means EGR fault cases from this part of Trafford are a routine part of our workload.
FAQs, EGR removal Urmston
Can you handle multiple vehicles in the same visit?
What if the vehicle has pre-existing fault codes that are not EGR-related?
What if the ECU will not communicate at the start of the job?
What is your coverage radius from Urmston?
EGR removal across Greater Manchester
Other areas we cover:
Arrange your mobile EGR removal in Urmston
Call 0161 694 7331 to arrange your mobile EGR removal in Urmston. Fleet enquiries are welcome, call to discuss multiple vehicles. The price is £220 per vehicle, fixed, covering the visit, remap, and verification. If a DPF delete is also needed, the combined price is £445, handled in a single visit.
For off-road and track use only.